Honda Civic manuals

Honda Civic Service Manual: Rear Door Quarter Glass Removal and Installation (4-door)

Honda Civic Service Manual / Body / Doors and Enclosures / Doors / Rear Door Quarter Glass Removal and Installation (4-door)

Removal

1. Rear Door Power Window Switch Panel

1.

Remove the power window switch panel (A).

2. Rear Door Panel

1.

Remove the inner handle cap (A).

2.

Remove the screw (A).

3.

Remove the screw (A).

4.

Remove the door panel (A).

3. Rear Door Plastic Cover

1.

Detach the harness clip (A).

2.

Remove the plastic cover (B).

4. Rear Door Rear Lower Channel

1.

Remove the screw (A) and the bolt (B).

2.

Remove the rear lower channel (A).

5. Rear Door Glass

1.

Remove the bolts (A).

2.

Remove the glass (A).

6. Rear Door Quarter Glass

1.

Remove the rear door quarter glass (A).

Installation

1. Rear Door Quarter Glass

1.

Install the rear door quarter glass (A).

2. Rear Door Glass

1.

Install the glass (A).

2.

Install the bolts (A).

3. Rear Door Rear Lower Channel

1.

Install the rear lower channel (A).

onmmlnmmto

2.

Install the screw (A) and the bolt (B).

4. Rear Door Glass - Adjustment

NOTE: Check the door weatherstrip and the glass run channel for damage or deterioration, and replace them if necessary.

1.

Place the vehicle on a firm, level surface when adjusting the door glass.

2.

Carefully lower the glass (A) until you can see the glass mounting bolts (B), then loosen them.

3.

Push the glass against the glass run channel, then tighten the glass mounting bolts.

4.

Check that the glass moves smoothly.

5.

Raise the glass fully, and check for gaps. Also make sure that the glass (A) contacts the glass run channel (B) evenly.

5. Rear Door Plastic Cover

1.

Install the plastic cover (A).

2.

Install the harness clip (B).

6. Rear Door Panel

1.

Install the door panel (A).

2.

Install the screw (A).

3.

Install the screw (A).

4.

Install the inner handle cap (A).

7. Rear Door Power Window Switch Panel

1.

Install the power window switch panel (A).

Rear Door Opening Seal Removal and Installation (4-door)
8371A0 LEFT 8381A0 RIGHT Removal 1. Rear Door Sill Trim 1. ...

Rear Door Sash Outer Trim Removal and Installation (4-door)
8291A7 LEFT 8301A7 RIGHT Removal 1. Rear Door Rear Sash Outer Trim 1. ...

See also:

Honda Civic Service Manual. Engine Oil Pump Removal and Installation (Except K24Z7)
111150 1. Battery Terminal - Disconnection 1. Make sure the ignition switch is in LOCK (0), or the vehicle ignition in the OFF mode. 2. Discon ...

© 2016-2018 Copyright www.hocivic.com