Honda Civic manuals

Honda Civic Service Manual: Rear Brake Drum Removal and Installation

Honda Civic Service Manual / Chassis / Brakes / Drum Brakes / Rear Brake Drum Removal and Installation

411123 LEFT


411126 RIGHT


411120 BOTH

1. Vehicle Lift

1.

Raise the vehicle on a lift, and make sure it is securely supported.

2. Rear Wheel

1.

Remove the rear wheel.

3. Rear Brake Drum


Frequent inhalation of brake shoe dust, regardless of material composition, could be hazardous to your health.

Avoid breathing dust particles.

Never use an air hose or brush to clean brake assemblies. Use an OSHA-approved vacuum cleaner.

1.

Release the parking brake.

2.

Remove the brake drum (A).

NOTE:

If necessary, turn the adjuster bolt (B) with a flat-tip screwdriver until the shoes become loose.

If the brake drum is stuck to the hub bearing unit, thread two 8 x 1.25 mm or 12 x 1.25 mm bolts (C) into the brake drum to push it away from the hub bearing unit. Turn each bolt 90 degrees at a time to prevent the brake drum from binding.

1. Rear Brake Drum

Frequent inhalation of brake shoe dust, regardless of material composition, could be hazardous to your health.

Avoid breathing dust particles.

Never use an air hose or brush to clean brake assemblies. Use an OSHA-approved vacuum cleaner.

1.

Install the brake drum (A).

NOTE:

Before installing the brake drum, clean the mating surfaces between the hub bearing unit and the inside of the brake drum.

After installation, press the brake pedal several times to make sure the brakes work and self adjust the brake shoes. Do not drive the vehicle before doing this procedure.

2. Rear Wheel

15mmumum

1.

Install the rear wheel.

NOTE: Before installing the wheel, clean the mating surfaces between the brake disc or the brake drum and the inside of the wheel.

Parking Brake Adjustment (Drum Brake)
1. Vehicle Lift 1. Raise the vehicle on a lift, and make sure it is securely supported. 2. ...

Rear Hub Bearing Unit Replacement (Drum Brake)
4181A0 LEFT 4181A1 RIGHT 4181A2 BOTH 1. Rear Knuckle/Hub Bearing Unit Exploded View Exploded View mmm.knuckles.smmnndsunssassemblvunuuni0i25mmm-mmu ...

See also:

Honda Civic Service Manual. Side Impact Sensor (Second) Removal and Installation (2-door)
7521C3 LEFT REAR 7521C4 RIGHT REAR Removal NOTE: SRS components are located in this area. Review the SRS component locations and the precautions and procedures before doing repairs or service. 1. Battery Terminal (SRS) - Disconnection ...

© 2016-2024 Copyright www.hocivic.com

0.0262